HEA gains independence with Nikiski plant

By Hannah Heimbuch
Homer Tribune

Photo provided by HEA About 100 HEA employees and members gathered in Nikiski Thursday for the dedication of the new Combined Cycle Plant.

Photo provided by HEA
About 100 HEA employees and members gathered in Nikiski Thursday for the dedication of the new Combined Cycle Plant.

May Day welcomed more than early summer weather last week, it also marked the dedication of a new Homer Electric Association plant in Nikiski. About 100 members and employees gathered at the Nikiski Combined Cycle Plant — which began operating the first of this year — to commemorate and tour the Nikiski plant and the Bernice Lake Combustion Turbine Plant.
“(It is) truly monumental in the history of Homer Electric Association,” said HEA Board of Directors President Dick Waisanen. The plant represents HEA’s transition into a new era in many ways, he said, both by its technology, and the independence it represents.
As of Jan. 1, when the plant came online, HEA officially became independent from wholesale supplier Chugach Electric Association.
“In the end, all of our lofty goals have been accomplished,” said Alaska Electric and Energy Cooperative President Bill Fry. “We are producing our own power, we are independent.”
That independence came with a boost in personnel, adding 34 full-time, long-term jobs to the HEA staff list. Some of those new positions are located at Power Dispatch in Nikiski, a state-of-the-art control center manned 24-7. Dispatch staff, posted in front of dozens of ever-changing information screens, match power generation to member load and maintain system frequency. This dispatch center connects HEA’s diverse power generation system, including the Bernice Lake plant. HEA purchased Bernice Lake from Chugach Electric in 2011. It uses three gas turbines to produce 80 megawatts of power.
The new plant at Nikiski also generates 80 megawatts of power, 18 of them produced by a new steam turbine. The steam turbine uses waste heat from the combustion turbine, converting the heat to usable energy that’s pumped back into the HEA grid without using any additional natural gas.
Plant Superintendent Larry Jorgensen describes a combustion turbine as a jet engine mounted on skids. The turbine capacity in Nikiski is equivalent to about 45,000 horsepower, he said. The Heat Recovery Steam Generator pulls the 950 to 1000 degree heat coming from that turbine, and converts it to steam — 370,000 pounds per hour at maximum capacity.
“That’s the energy savings,” Jorgensen said. “We’ll remove that heat, and convert it to power.”
Another strong feature of both the Nikiski plant and the Bernice Lake plant are their black start capacities. According to plant superintendent Jim Kingrey, the Bernice plant can go from cold to pumping power onto the grid in just five minutes, and up to capacity in another two minutes.
“So that’s a really good safety feature to have,” Jorgensen said. “We’re not dependent on anyone else to get this place running again.”

HOMER TRIBUNE/Hannah Heimbuch HEA led tours of its new plant at Nikiski. Here, HEA employees stand below the new steam turbine, which uses waste heat to create power without using additional natural gas.

HOMER TRIBUNE/Hannah Heimbuch
HEA led tours of its new plant at Nikiski. Here, HEA employees stand below the new steam turbine, which uses waste heat to create power without using additional natural gas.

The Bernice plant was built in 1963, but has gone through several major updates and overhauls in the decades since. One of those was installation of an arsenic removal skid in June of last year. The station cleans waste water before it is released back into the ground. The water actually comes out of the ground with a higher arsenic level than can legally be put back into the ground, Kingrey said, about 25 parts per million. Prior to the skid’s installation, waste water had to be hauled to Anchorage for cleaning. This added up to about 5,000 gallons every two or three days, Kingrey said, and cost about $1 per gallon to haul and clean.
Another great aspect of the Bernice site, Kingrey said, is its output flexibility, which can be adjusted depending on member demand.
“We can run this site basically from 2 megawatts all the way up to 80 megawatts,” Kingrey said.
Bernice Lake facilities can be remote operated from the Nikiski Power Dispatch. Part of that system includes the new Bernice Lake Transmission Substation, which came online last April. That station and a corresponding line loop give HEA the ability to keep more members powered up, even if one controller goes down. Previously, the two were on one line.
Following the day of tours and celebration, approximately 400 members gathered in Soldotna for the HEA annual meeting. Directors in all three districts ran for reelection unopposed.
Kelly Bookey will stay in the District 1 seat, covering Kenai, Nikiski and parts of Soldotna. Dick Waisanen will keep his District 2 seat, representing Soldotna, Sterling and the Kasilof area. For District 3, covering south Kasilof and the Kachemak Bay region, Don Seelinger of Seldovia will serve again.
For the coming year’s officers, the Board of Directors elected Waisanen as President, Bill Fry of Homer for Vice President, David Thomas of Kenai as Secretary/Treasurer, and Jim Levine of Homer as Deputy Secretary.
HEA has also announced youth recipients of its $1,000 scholarships. In District 3, recipients include Savely Kalugin of Voznesenka High School, Mattea Peters of Homer High School, Brian Rowe of Homer High School, and Deonisy Koney from the Other/Continuing Education Category.

Contact the writer
Posted by on May 6th, 2014 and filed under Headline News. You can follow any responses to this entry through the RSS 2.0. Both comments and pings are currently closed.

Comments are closed

Like us on Facebook